杨庄矿软岩巷道锚杆与钢管混凝土支架联合支护技术研究

采矿与安全工程学报 ›› 2015, Vol. 32 ›› Issue (2): 285-290.

杨庄矿软岩巷道锚杆与钢管混凝土支架联合支护技术研究

1．北京中煤矿山工程有限公司，北京 100013；2．中国矿业大学(北京)力学与建筑工程学院，北京 100083

收稿日期:2013-07-26 出版日期:2015-03-15 发布日期:2015-06-23
作者简介:李学彬(1981—)，男，山东省潍坊市人，博士，从事巷道支护方面的研究。
基金资助:
国家自然科学基金重点项目(51134025)

Study on combined support technology of bolt-mesh-shotcrete and concrete filled steel tubular supports for soft rock roadway in Yangzhuang mine

Received:2013-07-26 Online:2015-03-15 Published:2015-06-23

摘要/Abstract

摘要： 杨庄矿Ⅲ水平南大巷软岩巷道围岩强度低，黏土矿物含量高，吸水泥化现象严重，巷道围岩变形量大，锚杆失效较为普遍。结合南大巷软岩巷道围岩变形特点，设计了锚杆与钢管混凝土支架联合支护方案。巷道断面采用马蹄形，锚杆为Φ20 mm×L1800 mm 的左旋螺纹钢锚杆，钢管混凝土支架主体钢管选用Φ194 mm×L8 mm 无缝钢管，灌注C40 核心混凝土。结合理论计算可知，设计支护方案的极限承载能力大于南大巷围岩荷载，能够维持巷道围岩的稳定。通过数值分析和现场监测分析可知，巷道围岩变形较小，锚杆和钢管混凝土支架支护作用力均小于其极限荷载，支护结构稳定，所以锚杆与钢管混凝土支架联合支护方案满足了Ⅲ水平南大巷软岩巷道支护的要求。

关键词: 软岩巷道, 钢管混凝土支架, 理论分析, 数值模拟

Abstract: The sounding rock of Ⅲ-Level South Roadway was significantly affected by geological structure, lower roadway sounding rock strength, higher content of clay minerals, and serious argillization. Combined with deformation characteristics of South Roadway, the combined support of bolt and steel tubular confined concrete support (STCCS) has been designed as follows: roadway section is in horseshoe, with Φ20 mm×L1800 mm L-steel bolt, STCCS constituted by Φ194 mm×L8 mm seamless steel tube and C40 core concrete. Combined with theoretical calculation, the ultimate bearing capacity of the designed support programs is greater than the surrounding rock load of South Roadway, which can maintain the stability of roadway surrounding rock. By numerical analysis and on-site monitoring analysis, the final deformation of roadway sounding rock is small after roadway support scheme has been applied. The support force of bolt and STCCS was less than their limit load. Consequently, roadway support is stable and reliable. So the support programs reached the soft roadway support requirement of Ⅲ-Level South Roadway.

Key words: soft rock roadway, STCCS, theoretical analysis, numerical simulation

李学彬, 杨仁树, 高延法, 薛华俊. 杨庄矿软岩巷道锚杆与钢管混凝土支架联合支护技术研究[J]. 采矿与安全工程学报, 2015, 32(2): 285-290.

LI Xue-Bin, YANG Ren-Shu, GAO Yan-Fa, XUE Hua-Jun. Study on combined support technology of bolt-mesh-shotcrete and concrete filled steel tubular supports for soft rock roadway in Yangzhuang mine[J]. Journal of Mining & Safety Engineering, 2015, 32(2): 285-290.

[1]	鹿伟，江贝，王琦，孙会彬，黄玉兵，张朋. 深部软岩巷道方钢约束混凝土拱架基本构件力学特性及参数影响机制研究[J]. 采矿与安全工程学报, 2020, 37(3): 473-480.
[2]	夏方迁，王军. 抗弯强化型钢管混凝土支架支护技术研究[J]. 采矿与安全工程学报, 2020, 37(3): 490-497.
[3]	范磊，王卫军，袁超. 基于可拓学倾斜软岩巷道支护效果评价方法[J]. 采矿与安全工程学报, 2020, 37(3): 498-504.
[4]	潘卫东，姜鹏，许延春，李江华. 薄基岩近距离煤层开采“水-岩”致灾演变模型及规律研究[J]. 采矿与安全工程学报, 2020, 37(3): 543-552.
[5]	李青锋，彭跃金，吴昊，崔栋歌. 基于微震与矿山压力监测的工作面周期来压步距与机理分析[J]. 采矿与安全工程学报, 2020, 37(3): 571-577.
[6]	蒋威，鞠文君，汪占领，张镇. 厚硬基本顶综放沿空巷道受载变形机制研究[J]. 采矿与安全工程学报, 2020, 37(2): 319-326.
[7]	谭云亮，范德源，刘学生，李先锋，马庆，王洪磊，范文昌. 煤矿超大断面硐室判别方法及其工程特征[J]. 采矿与安全工程学报, 2020, 37(1): 23-31.
[8]	郭广礼，郭凯凯，张国建，李怀展，胡绍豪. 深部带状充填开采复合承载体变形特征研究[J]. 采矿与安全工程学报, 2020, 37(1): 101-109.
[9]	张悦刊，曹井振，刘培坤，李晓宇，杨兴华，王辉. 具有W型反射盘的新型干扰床分级机性能分析[J]. 采矿与安全工程学报, 2020, 37(1): 207-214.
[10]	吕可，王金安，李鹏波. 冲击地压巷道周边动力放大效应及支护参数调控策略[J]. 采矿与安全工程学报, 2019, 36(6): 1168-1177.
[11]	宋卫华，邸春雷，闫万俊，邓兆睿. 大断面矩形巷道过陷落柱构造带支护技术[J]. 采矿与安全工程学报, 2019, 36(6): 1178-1185.
[12]	郭文兵，娄高中，赵保才. 芦沟煤矿软硬交互覆岩放顶煤开采导水裂缝带高度研究[J]. 采矿与安全工程学报, 2019, 36(3): 519-526.
[13]	曹帅，薛改利，宋卫东,. 组合胶结充填体力学特性试验与应用研究[J]. 采矿与安全工程学报, 2019, 36(3): 601-608.
[14]	汪伟，罗周全，秦亚光，向军. 深孔落矿破顶层厚度综合确定方法及应用[J]. 采矿与安全工程学报, 2019, 36(1): 65-71.
[15]	郭玉，郑西贵，郭罡业，赵启峰，周伟，安铁梁. 近距离跨采软岩巷道围岩变形破坏控制研究[J]. 采矿与安全工程学报, 2018, 35(6): 1142-1149.